Two experiments were conducted in which the acute effects of inhaled methanol on serum hormones associated with reproductive function in the male rat were evaluated. In the first experiment, rats exposed to methanol (0, 200, 5000 and 10,000 ppm) for 6 h were killed at the end of the exposure period (6 h) or the following morning (24 h). Also, because the process of exposure itself could modify neuroendocrine function, the effect of the handling associated with placing the rat in the exposure chamber was evaluated further by dividing the exposed animals into acclimated (2 weeks of prior handling) and non-acclimated groups. At 6 h, an effect of prior handling was noted in the sham-exposed rats, with serum luteinizing hormone (LH) of the non-acclimated group being greater than that of the acclimated group. Serum LH concentrations were altered by methanol exposure, but the direction of change and the exposure level at which an effect was noted differed between the acclimated and non-acclimated rats. Methanol (5000 ppm) reduced serum LH in the non-acclimated animals, while 10,000 ppm increased LH in the acclimated rats. Follicle stimulating hormone (FSH) and testosterone were unchanged by methanol in rats killed at 6 h. Thus, this experiment did not confirm earlier reports that exposure to 200 ppm for 6 h reduced serum testosterone. At 24 h, an effect of prior handling was still present in the hormonal measures, with serum and interstitial fluid testosterone concentrations being greater in the non-acclimated rats. Also, there was a dose x handling interaction with methanol exposure inducing an increase in serum testosterone in the non-acclimated rats (up to 5000 ppm) and a decrease in the acclimated rats (up to 10,000 ppm). In the second experiment, groups of acclimated and non-acclimated rats were exposed to 0 or 5000 ppm methanol for 1, 2 and 6 h and killed immediately after removal from the chamber. Serum LH, testosterone and FSH values were not different in sham- vs methanol-exposed rats at any time point. As in experiment 1, an effect of prior handling was noted. In general, the concentrations of these hormones and serum prolactin in the non-acclimated rats were greater than those observed for acclimated rats. Methanol exposure resulted in increased prolactin concentrations under both handling conditions.(ABSTRACT TRUNCATED AT 400 WORDS)